威格士柱塞泵常見故障處理
1.柱塞泵輸出流量不足或不輸出油液
(1)吸入量不足。原因是吸油管路上的阻力過大或補油量不足。如泵的轉速過大，油箱中液面過低，進油管漏氣，濾油器堵塞等。
(2)泄漏量過大。原因是泵的間隙過大，密封不良造成。如配油盤被金屬碎片、鐵屑等劃傷，端面漏油;變量機構中的單向閥密封面配合不好，泵體和配油盤的支承面有砂眼或研痕等。可以通過檢查泵體內液壓油中混雜的異物判別泵被損壞的部位。
(3)傾斜盤傾角太小，泵的排量少，這需要調節變量活塞，增加斜盤傾角。
2.中位時排油量不為零 變量式軸向柱塞泵的斜盤傾角為零時稱為中位，此時泵的輸出流量應為零。但有時會出現中位偏離調整機構中點的現象，在中點時仍有流量輸出。其原因是控制器的位置偏離、松動或損傷，需要重新調零、緊固或更換。泵的角度維持力不夠、傾斜角耳軸磨損也會產生這種現象。
3.輸出流量波動 輸出流量波動與很多因素有關。對變量泵可以認為是變量機構的控制不佳造成，如異物進入變量機構，在控制活塞上劃出階痕、磨痕、傷痕等，造成控制活塞運動不穩定。由于放大器能量不足或零件損壞、含有彈簧的控制活塞的阻尼器效能差，都會造成控制活塞運動不穩定。流量不穩定又往往伴隨著壓力波動。這類故障一般要拆開液壓泵，更換受損零部件，加大阻尼，提高彈簧剛度和控制壓力等。
4.輸出壓力異常 泵的輸出壓力是由負載決定的，與輸入轉矩近似成正比。輸出壓力異常有兩種故障。
(1)輸出壓力過低 當泵在自吸狀態下，若進油管路漏氣或系統中液壓缸、單向閥、換向閥等有較大的泄漏，均會使壓力升不上去。這需要找出漏氣處，緊固、更換密封件，即可提高壓力。溢流閥有故障或調整壓力低，系統壓力也上不去，應重新調整壓力或檢修溢流閥。如果液壓泵的缸體與配流盤產生偏差造成大量泄漏，嚴重時，缸體可能破裂，則應重新研磨配合面或更換液壓泵。
(2)輸出壓力過高 若回路負載持續上升，泵的壓力也持續上升，當屬正常。若負載一定，泵的壓力超過負載所需壓力值，則應檢查泵以外的液壓元件，如方向閥、壓力閥、傳動裝置和回油管道。若最大壓力過高，應調整溢流閥。
5.振動和噪聲 振動和噪聲是同時出現的。它們不僅對機器的操作者造成危害，也對環境造成污染。
(1)機械振動和噪聲 如泵軸和電機軸不同心或頂死，旋轉軸的軸承、聯軸節損傷，彈性墊破損和裝配螺栓松動均會產生噪聲。對于高速運轉或傳輸大能量的泵，要定期檢查，記錄各部件的振幅、頻率和噪聲。如泵的轉動頻率與壓力閥的固有頻率相同時，將會引起共振，可改變泵的轉速以消除共振。
(2)管道內液流產生的噪聲 進油管道太細、進油濾油器通流能力過小或堵塞、進油管吸入空氣、油液豁度過高、油面過低吸油不足和高壓管道中產生液擊等，均會產生噪聲。因此，必須正確設計油箱，正確選擇濾油器、油管和方向閥。
6.威格士柱塞泵過熱 液壓泵過度發熱有兩個原因，一是機械摩擦生熱。由于運動表面處于干摩擦或半干摩擦狀態，運動部件相互摩擦生熱。二是液體摩擦生熱。高壓油通過各種縫隙泄漏到低壓腔，大量的液壓能損失轉為熱能。所以正確選擇運動部件之間的間隙、油箱容積和冷卻器，可以杜絕泵的過度發熱和油溫過高的現象。另外，回油過濾器堵塞造成回油背壓過高，也會引起油溫過高和泵體過熱。
7.漏油 柱塞泵漏油主要有以下原因:(1)主軸油封損壞或軸有缺陷、劃痕;(2)內部泄漏過大，造成油封處壓力增大，而將油封損傷或沖出;(3)泄油管過細過長，使密封處漏油;(4)泵的外接油管松動，管接頭損傷，密封墊老化或產生裂紋;(5)變量調節機構螺栓松動，密封破損;(6)鑄鐵泵殼有砂眼或焊接不良。
PVE19-B2R-STS1F-41-C21D-12
PVE19AR05AA10B312600A100100CD0A
PVE19-B2R-STS9F-41-C24VPC26B-13-158
PVE19AR05AA10B211100A100100CD0A
PVE19-B2R-STS9F-41-C21VP11B-13
PVE19AL05AA10B211100A100100CD0A
PVE19AR02AA10B211100A100100CD0A
PVE19-B2R-STS1F-41-C21VP11B-13
PVE19AL02AA10B211100A100100CD0A
PVE19-B2L-STS1F-41-C21VP11B-13
PVE19AL08AA10B211100A100100CD0A
PVE19-B2L-STS2F-41-C21VP11B-13
PVE19AR08AA10B211100A100100CD0A
PVE19-B2R-STS2F-41-C21VP11B-13
PVE19AR05AA10B212400A100100CD0A
PVE19-B2R-STS9F-41-C21VPC24B-13-CD
PVE19AL05AA10B212400A100100CD0A
PVE19-B2L-STS9F-41-C21VPC24B-13
PVE19AL08AA10A140000H100100CD0A
PVE19-B2L-STS2F-41-C14-12-061
PVE19AL15AA20A160000F100100CD0A
PVE19-B2L-STS5F-41-C15-12-010
PVE19AR05AB10A2100000200100CD0A
PVE19-B2R-STE9F-41-C21D-12
PVE21AL08AW21B33240001001AHCDAA
PVE21-B2L-MFE2F-41-C21VPC24P-13-317
PVE21AR08AS11B33240001001AHCDAA
PVE21-B2R-MFE2F-41-C21VPC24P-13-316
PVE21AR04AA10A3000000100100CD0A
PVE21-B2R-STS13F-41-C19-12
PVE21AR05AB10B27240001001AGCD0A
PVE21AL05AB10B27240001001AGCD0A
PVE21-B2L-STE9F-41-C20VPC24P-13-295
PVE21AR08AB10B212400A2001AFCD0A
PVE21AL14AA20B21170001001AECC3A
PVE21-B2L-STS30F-41-C21VPC17P-13-263
PVE21AR17AA10A2900000100100CC3A
PVE21-B2R-STS31F-41-C16-12-261
PVE21AR05AA10A1800000200100CD0A
PVE21-B2R-STS9F-41-C19D-12
PVE21AL05AD21E1924000100100CD0A
PVE21AL17AA20B3014000100100CC3A
PVE21AR02AA10A1800000200100CD0A
PVE21-B2R-STS1F-41-C19D-12
PVE21AR17AA10A2800000100100CC3A
PVE21-B2R-STS31F-41-C09-12-240
PVE21AL08AA10H1811000100100CD0A
PVE21-B2L-STS2F-41-C19VP11P-13-234
PVE21AR08AD21B3024000100100CDBA
PVE21-B2R-SFE2F-41-C19VPC24P-13-220
PVE21AL08AT21B3024000100100CDBA
4520V42A5 1CC22R
4520V42A11 1AB22R
4520V42A11 1AC22R
4520V42A12 1CC22R
4520V42A12 86DD22R
4520V50A5 1CC22R
4520V50A8 1CC22R
4520V50A11 1AA22R
4520V50A11 1CC22R
4520V50A12 1AA22R
4520V50A14-1AA22L
4520V60A5 1CC22R
4520V60A8 1AA22R
4520V60A8 1CC22R
4520V60A11 1AD22R
4520V60A12 1AA22R
4520V60A12 1CC22R
4520V60A14 1CC22R
4520VQ42A5 1CC22R
4520VQ42A11 1AB22R
4520VQ42A12 86DD22R
4520VQ50A5 1CC22R
4520VQ50A8 1CC22R
4520VQ50A11 1AA22R
4520VQ50A11 1CC22R
4520VQ50A12 1AA22R
4520VQ50A14-1AA22L
4520VQ60A5 1CC22R
4520VQ60A8 1AA22R
4520VQ60A8 1CC22R
4520VQ60A11 1AD22R
4520VQ60A12 1AA22R
4520VQ60A12 1CC22R
4520VQ60A14 1CC22R
4520V42A5-1CC22R
4520V42A11-1AB22R
4520V42A11-1AC22R
4520V42A12-1CC22R
4520V42A12-86DD22R
4520V50A5-1CC22R
4520V50A8-1CC22R
4520V50A11-1AA22R
4520V50A11-1CC22R
4520V50A12-1AA22R
4520V60A5-1CC22R
4520V60A8-1AA22R
4520V60A8-1CC22R
4520V60A11-1AD22R
4520V60A12-1AA22R
4520V60A12-1CC22R
4520V60A14-1CC22R
4520VQ60A8 86DD20
4520VQ60A8 86AA20
4520VQ60A8 11CC20
4520VQ60A12 11CC20
4520VQ60A11 86CC20
4520VQ50A8 86AA20
4520VQ50A11 11CC20
4520VQ42A8 11CC20
4520VQ42A11 1DC20
PVE19AR08AA10D01000001AE100CD0A
PVE19AR01AA10A140000E100100CD0A
PVH98QIC3-RF-1S-11-C25V-31
PVH131L13AJ30A070000002001AE010A
PVH131QIC-LSF-13S-11-CM7-31
PVH131R16AF30E252004001AD1AE010A
PVH131QIC-RAF-16S-11-C25VT4-31
PVH098R02AJ30A250000001AD1AA010A
PVH98C-RAF-2S-11-C25-31-036
PVH074R03AA10B252000001AP1AA010A
PVH74C-RCF-3S-11-C25V-31
PVH131L03AF30E252004001AD1AA010A
PVH131C-LAF-3S-11-C25VT4-31
PVH098R63AJ30E252004001AD1AE010A
PVH98QIC2-RAF-13S-11-C25VT4-31
PVH098L53AJ30E252004001AD1AA010A
PVH98C2-LAF-3S-11-C25VT4-31
PVH074R63AA10E252004001AF1AE010A
PVH74QIC2-RAF-13S-11-C25VT4-31
PVH074L53AA10E252004001AF1AA010A
PVH74C2-LAF-3S-11-C25VT4-31
PVH057L52AA10E252004001AE1AA010A
PVH57C2-LAF-2S-11-C25VT4-31
PVH074R01AA10D250014001001AA010A
PVH74C-RF-1S-11-C25T14-31
PVH098L02AJ30B102000AG1AD1AA010A
PVH98C-LAF-2S-11-C10V-31-036
PVH074L02AA10B122000AG1002AA010A
PVH74C-LF-2D-11-C12V-31
PVH074R02AA10E252014001001AA010A
PVH74C-RF-2S-11-C25VT17-31
PVH074R13AA10A070000001AF1AF010A
PVH74QPC-RAF-13S-11-CM7-31
PVH131R03AF30E252008001AD1AA010A
PVH131C-RAF-3S-11-C25VT8-31
PVH098R13AJ70B252000001AD1AE010A
PVH98QIC3-RAF-13S-11-C25V-31
PVH098R51AD30A070000002001AF010A
PVH98QPC2-RSM-1S-11-CM7-31
PVH098R02AJ30D250004001002AE010A
PVH98QIC-RF-2D-11-C25T4-31
PVH074R01AB10A070000002001AE010A
PVH74QIC-RSM-1S-11-CM7-31
PVH098R13AJ70A250000001AD1AE010A
PVH98QIC3-RAF-13S-11-C25-31
PVH098R03AJ30A250000001AD2AA010A
PVH98C-RAF-3D-11-C25-31
PVH074L02AB10B252000001001AA010A
PVH74C-LM-2S-11-C25V-31
PVH074L02AB10B252000001AF1AA010A
PVH74C-LAM-2S-11-C25V-31-036
PVH074R0NAB10A070000001001AF010A
PVH74QPM-RM-NS-11-CM7-31
PVH074R51AB10A070000002001AE010A
PVH74QIC2-RSM-1S-11-CM7-31
PVH057L52AA10B252000001001AA010A
PVH57C2-LF-2S-11-C25V-31
PVH131L02AF30B252000001002AA010A
PVH131C-LF-2D-11-C25V-31
PVH074R13AA10E252007001AF1AE010A
PVH74QIC-RAF-13S-11-C25VT7-31
PVH057R02AA10E252007001001AE010A
PVH57QIC-RF-2S-11-C25VT7-31
PVH074R01AA10B252000001001AN010A
PVH74C-RF-1S-11-C25V-31-115
PVH098R01AJ30A250000001001AN010A
PVH98C-RF-1S-11-C25-31-115
PVH057R02AA10A150000001AE2AA010A
PVH57C-RAF-2D-11-C15-31
PVH098R01AJ30D250005001001BC010A
PVH98QIC-RF-1S-11-C25T5-31-115
PVH098L02AJ30B102000AG1001AA010A
PVH98C-LF-2S-11-C10V-31
PVH074R02AA10A190000001AP2AA010A
PVH74C-RCF-2D-11-C19-31-036
PVH074R02AA10A190000001002AA010A
PVH74C-RF-2D-11-C19-31
PVH098L02AJ30A100000AG1001AA010A
PVH98C-LF-2S-11-C10-31
PVH074L02AA10A190000001002AA010A
PVH74C-LF-2D-11-C19-31
PVH098R02AJ30A250000001002AA010A
